Vought F7U Cutlass

F7U Cutlass
An F7U-3 Cutlass on the ramp at Naval Air Station Jacksonville.
Role	Naval multirole fighter
Manufacturer	Chance Vought
First flight	29 September 1948
Introduction	July 1951
Retired	2 March 1959
Primary user	United States Navy
Produced	1948-1955
Number built	320

The Vought F7U Cutlass was a United States Navy carrier-based jet fighter and fighter-bomber of the early Cold War era. It was a highly unusual, semi-tailless design, allegedly based on aerodynamic data and plans captured from the German Arado company at the end of World War II, though Vought designers denied any link to the German research at the time.^[1] The F7U was the last aircraft designed by Rex Beisel, who was responsible for the first fighter ever designed specifically for the US Navy, the Curtiss TS-1 of 1922.

Regarded as a radical departure from traditional aircraft design, the Cutlass suffered from numerous technical and handling problems throughout its short service career. The type was responsible for the deaths of four test pilots and 21 other U.S. Navy pilots.^[1] Over one quarter of all Cutlasses built were destroyed in accidents. The poor safety record was largely the result of the advanced design built to apply new aerodynamic theories and insufficiently powerful, unreliable engines.

Design and development

The first F7U-1 launching from the USS Midway in 1951

The Cutlass was Vought's entry to a U.S. Navy competition for a new carrier capable day fighter opened on 1 June 1945. The requirements were for an aircraft that was able to fly at 600 mph (966 km/h) at 40,000 ft (12,192 m).^[1] The design featured broad chord, low aspect ratio, swept wings, with twin wing-mounted tail fins either side of a short fuselage. The cockpit was situated well forward to provide good visibility for the pilot during aircraft carrier approaches. The design was given the company type number of V-346 and then the designation F7U when it was announced the winner of the competition.^[1]

Pitch and roll control was provided by elevons, though Vought called these surfaces "ailevators" at the time. Slats were fitted to the entire span of the leading edge. All controls were hydraulically-powered. The very long nose landing gear strut required for high angle of attack takeoffs was rather weak, and a collapse could seriously jeopardize the pilot's safety. The F7U was also largely let down by its underpowered Westinghouse turbojets, an engine which some pilots wryly observed put out less heat than the same company's toasters. Naval aviators referred to the F7U as the "gutless cutlass" or, in kinder moments, as the "praying mantis".^[2]

Operational history

Vought F7U-3 Cutlass

Ramp strike of a VF-124 F7U-3 on the USS Hancock on 14 July 1955 resulting in the death of the pilot but only relatively minor injuries to deck crew.^[3]

Three prototypes were ordered in 1946, with the first example flying on 29 September 1948, piloted by Vought's Chief Test Pilot, J. Robert Baker. The maiden flight took place from Naval Air Station Patuxent River and was not without its problems. During testing one of the protypes reached a maximum speed of 625 mph (1,058 km/h)^[4]

Production orders were placed for the F7U-1 in a specification very close to the prototypes, and further developed F7U-2 and F7U-3 versions with more powerful engines. Because of development problems with the powerplant, however, the F7U-2 would never be built, while the F7U-3 would incorporate many refinements suggested by tests of the -1. The first 16 F7U-3s had non-afterburning Allison J35-29 engines. The -3 with its Westinghouse J46-WE-8B turbojets would eventually become the definitive production version, with 288 aircraft equipping 13 U.S. Navy squadrons. Further development stopped once the Vought F8U Crusader flew.

The F7U bore the fleet nickname of the Gutless Cutlass in reference to its lack of sufficient engine thrust; consequently its carrier landing and takeoff performance was notoriously poor. The J35 was actually known to flameout in the rain, a very serious fault.

The first fleet squadron to receive F7Us was Fighter Squadron 81 (VF-81) in April 1954; the last with Cutlasses was Attack Squadron 66 (VA-66) in November 1957. Few squadrons made deployments with the type, and most "beached" them ashore during part of the cruise owing to operating difficulties. Those units known to have taken the type to sea were:

Fighter Squadron 124 (VF-124), USS Hancock (CVA-19), August 1955 - March 1956; Fighter Squadron 81 (VF-81), USS Ticonderoga (CVA-14), November 1955 - August 1956; Attack Squadron 86 (VA-86), USS Forrestal (CVA-59), January - March 1956 Shakedown Cruise; Attack Squadron 83 (VA-83), USS Intrepid (CVA-11), March - September 1956; VA-116, USS Hancock (CVA-19), Attack Squadron 151 (VA-151), USS Lexington (CVA-16), Attack Squadron 212 (VA-212), USS Bon Homme Richard (CVA-31), August 1956 - February 1957. Air Test and Evaluation Squadron 4 (VX-4), USS Shangri-La (CVA-38) and USS Lexington (CVA-16),

Blue Angels

The Navy Flight Demonstration Squadron, the Blue Angels, flew two F7U-1 Cutlasses as a side demonstration during their 1953 show season in an effort to promote the new aircraft, but did not use them as part of their regular formation demonstration. Both the pilots and ground crews found the aircraft generally unsatisfactory and it was apparent that the type was still experiencing teething troubles.^[4]

During the Blue Angels' first airshow appearance in 1953, pilot LT Edward "Whitey" Feightner, the former program manager for the F7U, experienced a total loss of hydraulics on a full afterburner takeoff and steep climb. While trying to gain enough altitude for ejection he was able to stay with the aircraft until the back up system came on. He clipped trees on the end of the runway, causing the left engine to flame out. With hydraulic fluid streaming back in a bright flame, he made a hard turn and got the plane back on the runway, much to the excitement of the crowd. Later, while traveling to an airshow at Naval Air Station Glenview in Chicago, Illinois, Blue Angel pilot LT Harding MacKnight experienced an engine flameout in his Cutlass, forcing him to make an emergency landing at NAS Glenview. Traveling with him, LT "Whitey" Feightner was redirected to make his landing at Chicago's former Orchard Airpark, which had been expanded and renamed O'Hare Airport. The runway had just been completed and was covered with peach baskets to prevent aircraft from landing until it was opened. LT Feightner was told to ignore the baskets and land on the new runway. As a result, LT Feightner's F7U became the first aircraft to land on the new runway for Chicago's O'Hare International Airport.

Following these incidents, the two F7U were deemed unsuitable for demonstration flying and were flown to Naval Air Station Memphis, Tennessee, where they were abandoned to become aircraft maintenance instructional airframes for the Naval Technical Training Center.^[5]

Variants

XF7U-1

Three prototypes ordered on 25 June 1946. First flight, 29 September 1948, all three aircraft were destroyed in crashes.^[6]

F7U-1

The initial production version, 14 built. Powered by two J34-WE-32 engines.

F7U-2

Proposed version, planned to be powered by two Westinghouse J34-WE-42 engines with afterburner, but the order for 88 aircraft was cancelled.

XF7U-3

Designation given to one aircraft built as the prototype for the F7U-3, BuNo 128451. First flight: 20 December 1951.

F7U-3

The definitive production version, 192 built.

F7U-3P reconnaissance aircraft

F7U-3P

Photo-reconnaissance version, 12 built. With a 25 in longer nose and equipped with photo flash cartridges none of these aircraft saw operational service, being used only for research and evaluation purposes.^[6]

F7U-3M

This missile capable version was armed with four AAM-N-2 Sparrow I air-to-air beam-riding missiles, 98 built. A total of 48 F7U-3 existing airframes were upgraded to F7U-3M standard. An order for 202 aircraft was cancelled.

A2U-1

Designation given to a cancelled order of 250 aircraft to be used in the ground attack role.

Operators

A VF-83 F7U-3 launches from the USS Intrepid in 1954 during catapult testing

 United States

• • VC-3
  • VX-3
  • VX-4
  • VX-5
  • VA-12
  • VA-34
  • VF-81 / VA-66
  • VF-83 / VA-83
  • VA-86
  • VA-116
  • VF-122
  • VF-124
  • VA-126
  • VF-151 / VA-151
  • VF-212 / VA-212

Survivors

Seven F7U Cutlass aircraft are known to have survived.

F7U-3 BuNo 128451

Prototype F7U-3. Formerly at the Fred E. Weisbroad Aviation Museum/International B-24 Museum in Pueblo, Colorado. It was unrestored and incomplete, in poor condition. It is now at the USS Midway (CV-41) Museum in San Diego, California, to be combined with BuNo 129565 to make one complete aircraft.

F7U-3 BuNo 129554

Purchased by Len Berryman from Geiger Field, Washington in May 1958 and displayed outside the Berryman War Memorial Park in Bridgeport, Washington from 1958 until 1992. In June 1992 it was sold to Tom Cathcart of Ephrata, Washington for restoration to eventual flying condition. This aircraft is currently undergoing restoration at the Museum of Flight in Everett, Washington.

F7U-3 BuNo 129565

Was undergoing restoration for display at the USS Hornet (CV-12) Museum at the former NAS Alameda in Alameda, California. Has now been transferred to USS Midway (CV-41) Museum in San Diego, California for final restoration and display.

F7U-3 BuNo 129622

Ex VA-34 / VA-12 aircraft that was flown to Naval Air Reserve Training Unit (NARTU) Glenview, NAS Glenview, Illinois, where it was sporadically flown by Naval Air Reserve pilots and used for instruction of enlisted Naval Reserve aircraft maintenance personnel; ownership was then transferred to the Northbrook East Civic Association and the aircraft was moved to the Oaklane Elementary School for playground use. It was subsequently removed and dissected to be sold for its engines. Forward fuselage was part of Earl Reinart's collection in Mundelein, Illinois, while the rest of the aircraft went to J-46 dragster builder Fred Sibley in Elkhart, Inidana. Its components are currently reunited in the collection of noted F7U historian Al Casby of Phoenix, Arizona.

F7U-3M at the National Museum of Naval Aviation at NAS Pensacola, Florida

F7U-3 BuNo 129642

On display at the Wings of Freedom Aviation Museum at the Naval Air Station Joint Reserve Base Willow Grove, Pennsylvania. The aircraft belonged to Attack Squadron 12 (VA-12) and was flown to NAS Willow Grove in May 1957 to take part in an air show. Upon arrival the aircraft was stricken from active duty. It was transferred to the Naval Reserve for use as a ground training aircraft, and eventually placed as a gate guard in front of the base on US Route 611. The airframe has only 326.3 hours total flight time.

F7U-3 BuNo 129655

Although marked as an F7U-3M, this aircraft on display at the National Museum of Naval Aviation at NAS Pensacola, Florida is in reality an F7U-3 which was factory upgraded to F7U-3M standards. Formerly displayed at Griffith Park, California.

F7U-3 BuNo 129685

Located for many years at the aircraft collection of Walter Soplata in Newbury, Ohio.^[7] Like most aircraft on this famous farm, the aircraft appears complete, though it is exposed to the elements and unrestored.

Specifications (F7U-3M)

Data from Jane's Encyclopedia of Aviation^[8]

General characteristics

• Crew: 1
• Length: 44 ft 3 in (13.49 m)
• Wingspan: 38 ft 8 in (11.79 m)
• Height: 14 ft 0 in (4.27 m)
• Wing area: 496 ft² (46.1 m²)
• Empty weight: 18,210 lb (8,260 kg)
• Max takeoff weight: 31,642 lb (14,353 kg)
• Powerplant: 2 × Westinghouse J46-WE-8A turbojets, 4,600 lbf (20.46 kN) each

Performance

• Maximum speed:
  
  • Clean: 680 mph (590 kn, 1,095 km/h)
  • With missiles: 648 mph (562 kn, 1,040 km/h)
• Range: 660 mi (570 nmi, 1,060 km)
• Service ceiling: 40,000 ft (12,000 m)
• Rate of climb: 13,000 ft/min (67 m/s)
• Wing loading: 64 lb/ft² (312 kg/m²)
• Thrust/weight: 0.29

Armament

• Guns: 4× 20 mm (0.787 in) M3 cannons above inlet ducts, 180 rounds/gun
• Hardpoints: 4 with a capacity of 5,500 lb (2,500 kg) and provisions to carry combinations of:
  • Missiles: 4 AAM-N-2 Sparrow I air-to-air missiles

See also

Aircraft of comparable role, configuration and era

• Douglas F4D Skyray
• LTV A-7 Corsair II
• Vought F-8 Crusader
  

Related lists

• List of fighter aircraft
• List of military aircraft of the United States
  

References

Notes

1. ^ ^{a b c d} Angelucci 1987, p. 447.
2. ^ O'Rourke, G.G, CAPT USN. "Of Hosenoses, Stoofs, and Lefthanded Spads." United States Naval Institute Proceedings, July 1968.
3. ^ "F7U Cutlass Ramp Strike." liveleak.com. Retrieved: 5 October 2009.
4. ^ ^{a b} Angelluci, 1987. p. 448.
5. ^ Powell 2008, p. 37.
6. ^ ^{a b} Gunston 1981, p. 235.
7. ^ "Walter's farm." aircraftresourcecenter.com. Retrieved: 25 February 2008.
8. ^ Taylor 1993, pp. 253–254.

Bibliography

• Angelucci, Enzo. The American Fighter. Sparkford, Somerset, UK: Haynes Publishing Group, 1987. ISBN 0-85429-635-2.
• Ginter, Steve. Chance Vought F7U Cutlass (Naval Fighters Number Six). Simi Valley, California: Ginter Books, 1982. ISBN 0-942612-06-X.
• Green, William and Gerald Pollinger. The Aircraft of the World. London: Macdonald, 1955.
• Gunston, Bill. Fighters of the Fifties. Cambridge, UK: Patrick Stephens Limited, 1981. ISBN 0-85059-463-4.
• Powell, R.R. "Boom". "Cutlass Tales". Flight Journal, Volume 13, Issue 4, August 2008.
• Taylor, John W. R. "Vought F7U Cutlass". Combat Aircraft of the World from 1909 to the Present. New York: G.P. Putnam's Sons, 1969. ISBN 0-425-03633-2.
• Taylor, Michael J.H., ed. "Chance Vought F7U Cutlass". Jane’s Encyclopedia of Aviation. New York: Crescent, 1993. ISBN 0-517-10316-8.
• Winchester, Jim, ed. "Vought F7U Cutlass". The World's Worst Aircraft: From Pioneering Failures to Multimillion Dollar Disasters. London: Amber Books Ltd., 2005. ISBN 1-904687-34-2.

External links

• Vought Aircraft Industries, F-7U Photo Gallery