Colloidal silica

Colloidal silica

Colloidal silicas are suspensions of fine amorphous, nonporous, and typically spherical silica particles in a liquid phase.

Contents

Properties

Usually they are suspended in an aqueous phase that is stabilized electrostatically. Colloidal silicas exhibit particle densities in the range of 2.1 to 2.3 g/cm3.

Most colloidal silicas are prepared as monodisperse suspensions with particle sizes ranging from approximately 30 to 100 nm in diameter. Polydisperse suspensions can also be synthesized and have roughly the same limits in particle size. Smaller particles are difficult to stabilize while particles much greater than 150 nanometers are subject to sedimentation.

Manufacture

Colloidal silicas are most often prepared in a multi-step process where an alkali-silicate solution is partially neutralized, leading to the formation of silica nuclei. The subunits of colloidal silica particles are typically in the range of 1 to 5 nm. Whether or not these subunits are joined together depends on the conditions of polymerization. Initial acidification of a water-glass (sodium silicate) solution yields Si(OH)4.

If the pH is reduced below 7 or if salt is added, then the units tend to fuse together in chains. These products are often called silica gels. If the pH is kept slightly on the alkaline side of neutral, then the subunits stay separated, and they gradually grow. These products are often called precipitated silica or silica sols. Hydrogen ions from the surface of colloidal silica tend to dissociate in aqueous solution, yielding a high negative charge. Substitution of some of the Si atoms by Al is known increase the negative colloidal charge, especially when it is evaluated at pH below the neutral point. Because of the very small size, the surface area of colloidal silica is very high.

The colloidal suspension is stabilized by pH adjustment and then concentrated, usually by evaporation. The maximum concentration obtainable depends on the on particle size. For example, 50 nm particles can be concentrated to greater than 50 wt% solids while 10 nm particles can only be concentrated to approximately 30 wt% solids before the suspension becomes too unstable.

Applications

  • In papermaking colloidal silica is used as a drainage aid. It increases the amount of cationic starch that can be retained in the paper. Cationic starch is added as sizing agent to increase the dry strength of the paper.
  • High temperature binders
  • Investment casting - used in moulds
  • An abrasive - for polishing silicon wafers
  • Carbonless paper
  • Catalysts
  • Moisture Absorbent
  • It increases the bulk & taped density of powder & granules also
  • It is also be used in Lubrication of Tablet
  • Stabilizing and rigidizing refractory ceramic fiber (fiberfrax) blankets
  • Abrasion-resistant coatings
  • Increasing friction - used to coat waxed floors, textile fibers and railway tracks to promote traction
  • Antisoiling – fills micropores to prevent take up of dirt and other particles into textiles
  • Surfactant – used for flocculating, coagulating, dispersing, stabilizing etc.
    • Liquid silicon dioxide (colloidal silica) is used as a wine and juice fining agent.
  • Absorbent
  • Colloidal silica is used in concrete densifiers and polished concrete.
  • In manufacturing Quantum dots, small semi-conductors used in various scientific research settings.

See also


Wikimedia Foundation. 2010.

Игры ⚽ Нужно сделать НИР?

Look at other dictionaries:

  • silica gel — n colloidal silica resembling coarse white sand in appearance but possessing many fine pores and therefore extremely adsorbent * * * a purified form of silica (silicon dioxide) obtained by the reaction of sodium silicate with a mineral acid; used …   Medical dictionary

  • Colloidal crystal — A colloidal crystal is an ordered array of colloid particles, analogous to a standard crystal whose repeating subunits are atoms or molecules.[1] A natural example of this phenomenon can be found in the gem opal, where spheres of silica assume a… …   Wikipedia

  • Silica fume — Not to be confused with fumed silica. Silica fume, 380m²/g Silica fume, also known as microsilica, is a fine grain, thin, and very high surface area silica. It is sometimes confused with fumed silica (also known as pyrogenic silica) and colloidal …   Wikipedia

  • silica aerogel — noun : colloidal silica in the form of a fine lightweight powder with grains having minute pores that is made from silica gel and used chiefly as thermal insulation especially at low temperatures (as in refrigerators) …   Useful english dictionary

  • silica gel — noun Date: 1919 colloidal silica resembling coarse white sand in appearance but possessing many fine pores and therefore extremely adsorbent …   New Collegiate Dictionary

  • Colloïdal — Colloïde Le lait est une solution colloïdale de globules gras dans une solution à base d eau. Un colloïde est une substance sous forme de liquide ou galénique semi solide sous laquelle peuvent se présenter des préparations pharmaceutiques,… …   Wikipédia en Français

  • colloidal silicon dioxide — [NF] a submicroscopic fumed silica prepared by the vapor phase hydrolysis of a silicon compound; used as a tablet diluent and as a suspending and thickening agent …   Medical dictionary

  • État colloïdal — Colloïde Le lait est une solution colloïdale de globules gras dans une solution à base d eau. Un colloïde est une substance sous forme de liquide ou galénique semi solide sous laquelle peuvent se présenter des préparations pharmaceutiques,… …   Wikipédia en Français

  • Silicon dioxide — Silica redirects here. For other uses, see Silica (disambiguation). Silicon dioxide …   Wikipedia

  • Nanoparticle — In nanotechnology, a particle is defined as a small object that behaves as a whole unit in terms of its transport and properties. Particles are further classified according to size[1] : in terms of diameter, coarse particles cover a range… …   Wikipedia

Share the article and excerpts

Direct link
… Do a right-click on the link above
and select “Copy Link”