Lime plaster

Lime plaster

Lime plaster is a mixture of calcium hydroxide and sand (or other inert [http://en.wikipedia.org/wiki/Filler_(materials) filler materials] ). Carbon dioxide in the atmosphere causes the plaster to set by transforming the calcium hydroxide into calcium carbonate (limestone). Whitewash is based on the same chemistry.

To make lime plaster, Limestone (calcium carbonate) is heated to produce quicklime (calcium oxide). Water is then added to produce slaked lime (calcium hydroxide), which is sold as a white powder. Additional water is added to form a paste prior to use. The paste may be stored in air-tight containers. Once exposed to the atmosphere, the calcium hydroxide turns back into limestone, causing the plaster to set.

Lime plaster is used for true frescoes. Pigments, diluted in water, are applied to the still wet plaster. Modern stucco, which incorporates Portland cement is incorrectly also referred to as lime plaster. [ cite web|url= http://www.buildinggreentv.com/node/171 |title= What is lime plaster? |accessdate= 2008-08-12 |last= Couvreux |first= Michel |work= Building Green ]

Lime Mortar

Lime-and-sand-only mortars are more plastic and better accommodate any settling or movement in the wall than cements, which do not adjust to changes around them once they set. Although lime stuccoes and limewashes are more breathable, they also have better water shedding characteristics. Cement stucco is likely to crack under stress or movement, allowing a route for water infiltration into the interior where it will be trapped. In contrast, lime stucco can better adjust to early movements in the building because it does not set fully all the way through immediately, but only as the interior more slowly carbonates. Any tiny cracks that open can be resealed as acidic rainwater entering those cracks either draws some of the remaining calcium hydroxide into the crack, or, as the slightly acidic rainwater partially dissolves calcium carbonate along the edge of the crack, temporarily creating calcium bicarbonate, re-deposits it toward the front of the crack as calcium carbonate again. This self-healing characteristic of lime is well described in the literature as “autogenous healing”. [Hagsten, Ellen. "General Guidelines for Working with Lime Mortar and Limewash", Traditional & Sustainable Building, March 2007]

Limewash

"Unlike modern paints, which lay on the surface of the substrate, limewash instead acts like a stain by penetrating deep into the pores of the underlying material. This process creates a peel-free, breathable surface, and the limewash remains vapor permeable after it cures. It is a beautiful, traditional material that mellows while it gradually wears away, and over time it develops the weathered patina that characterizes the Old-World charm of Europe." [John Speweik, U.S. Heritage group]

Hydraulic Lime

Hydraulic Lime sets as a reaction with water and, as a generalisation, is used in areas likely to be exposed to weathering before full setting could otherwise take place. Hydraulic Lime has an initial set with water, much like cement, and a second set through carbonation, like non hydraulic lime . This allows for simplicity in application, identical to ordinary stucco.

Non-hydraulic lime can only set through carbonation (re-absorption of CO2). It is often sold in builder's merchants as 'bagged' or hydrated lime or is available as lime putty (or as quicklime to be made into lime putty), lime putty generally being considered more suitable for pure lime application. Non-hydraulic lime is the most commonly used and known lime, also called (high) calcium lime or air lime, as it sets only by reaction with CO2 in the air and will not set until dry. This causes limitations in construction use as the lime can remain soft for months or years.

Some kind of Hydraulic Lime was used for most of our old structures—many dating back several centuries. Its durability or longevity has been unsurpassed by any modern material, including cement stucco or “lime-based plasters.” This is simply due to its composition (calcium carbonate or limestone), resistance to salts (no sulphate attack or alkali-silica reactions), elasticity (reduces the risk of cracking and water intrusion), and breathability (does not trap water and allows its elimination through vapor exchange). A true lime plaster has the unique quality of reflecting multi-nuances of color, enhanced by the varied angles of sunlight reflected throughout the day.

Hydraulic and hydrated limes must not be confused. Hydrated lime is merely a form that lime can be supplied in (as opposed to quicklime or lime putty) while 'hydraulic' refers to a characteristic of the lime.

Safety issues

Lime is an extremely caustic material when wet, with a pH of 12. (Lime becomes pH neutral when carbonated). Protective goggles and gloves should be worn at all times. Additionally, protective clothing should be worn where risk of splatter on to bare skin is present.

Clean water should always be at arms length if lime gets in someone’s eyes or on their skin. Skin can be neutralized with a very mild acid such as vinegar or lemon juice. Repeatedly flush eyes with fresh water for several minutes and consult medical advice. [Hagsten, Ellen. "General Guidelines for Working with Lime Mortar and Limewash", Traditional & Sustainable Building, March 2007]

Use in the arts

One of the earliest examples of lime plaster dates back to the end of the eighth millennium BC. Three statues were discovered in a buried pit at 'Ain Ghazal in Jordan that were sculpted with lime plaster over armatures of reeds and twine. They were made in the pre-pottery neolithic period, around 7200 BC. The fact that these sculptures have lasted so long is a testament to the durability of lime plaster. [J.N. Tubb, "Canaanites", London, The British Museum Press, 1998]

Use in architecture

Some of the earliest known examples of lime use for building purposes are in early Egyptian buildings (primarily monuments). Some of these examples in the chambers of the pyramids, which date back to around 2000 B.C., are still hard and intact. Archaeological digs carried out on the island of Malta have shown that in places like Tarxien and Hagar, lime stucco was also used as a binder to hold stone together as well as for decoration at sites dating back as far as 3000-2500 B.C. At el-Amarna, a large pavement on brick was discovered that dates back to 1400 B.C. It was apparently the floor of part of the harem of King Amenhotep IV. [Cowper, Ad. "Lime and Lime Mortars", first published for the Building Research Station by HM Stationery Office, London, 1927] Ancient Chinese used Suk-wui (the Chinese word for slaked lime) in the construction of The Great Wall of China.

See also

* Lime mortar
* Plaster
* Limestone
* Whitewash
* Fresco
* Faux Finishing
* gypsum

References

Further reading

Cedar Rose Guelberth and Dan Chiras, "The Natural Plaster Book: "earth, lime and gypsum plasters for natural homes""

J.N. Tubb, "Canaanites", London, The British Museum Press, 1998

Stafford Holmes, Michael Wingate, "Building With Lime: A Practical Introduction", Intermediate Technology Publications Ltd,

External links

[http://www.howardhallfarm.com/limemortar.html "General Guidelines for Working with Lime Mortar and Limewash", Ellen Hagsten,Traditional & Sustainable Building, March 2007]

[http://www.britishmuseum.org/explore/highlights/highlight_objects/me/l/lime_plaster_statues.aspx British Museum: Lime Plaster Statues]

[http://www.jstor.org/pss/530161 Yuval Goren, Paul Goldberg, Peter W. Stahl and Udo H. BrinkerJournal of Field Archaeology, Vol. 18, No. 1 (Spring, 1991), pp. 131-140, Published by: Boston University]


Wikimedia Foundation. 2010.

Игры ⚽ Нужно сделать НИР?

Look at other dictionaries:

  • Plaster — The term plaster can refer to plaster of Paris, lime plaster, or cement plaster. This article deals mainly with plaster of Paris.Plaster of Paris is a type of building material based on calcium sulfate hemihydrate, nominally CaSO4·0.5H2O. It is… …   Wikipedia

  • plaster — I (New American Roget s College Thesaurus) n. plaster of paris, mortar, parget, stucco, gesso; paste, lime; clay, adobe, mud; poultice, dressing, bandage. See materials, connection, remedy. v. t. coat, cover, conceal, smear; caulk, repair, mend;… …   English dictionary for students

  • Lime — NOTOC Lime may refer to:Fruits*Lime (fruit), various green to yellow citrus fruits **Australian lime **Blood lime **Kaffir lime **Key lime **Persian lime **Spanish lime **Sweet lime **Wild lime *Lime tree, a common name for members of the genus… …   Wikipedia

  • Lime (material) — For other uses, see Lime (disambiguation). Limestone quarry in Brønnøy, Norway. Lime is a general term for calcium containing inorganic materials, in which carbonates, oxides and hydroxides predominate. Strictly speaking, lime is calcium oxide or …   Wikipedia

  • Lime mortar — is a type of mortar. It was used in the construction of the vast majority of brick and stone buildings worldwide from ancient times until the widespread adoption of Portland cement in the late nineteenth century. It is still used today, for the… …   Wikipedia

  • Plaster — Plas ter, n. [AS., a plaster (in sense 1), fr. L. emplastrum, Gr. ?, ?, fr. ? to daub on, stuff in; ? in + ? to mold: cf. OF. plastre a plaster (in sense 2), F. pl[^a]tre. Cf. {Plastic}, {Emplaster}, {Piaster}.] [Formerly written also… …   The Collaborative International Dictionary of English

  • Plaster cast — Plaster Plas ter, n. [AS., a plaster (in sense 1), fr. L. emplastrum, Gr. ?, ?, fr. ? to daub on, stuff in; ? in + ? to mold: cf. OF. plastre a plaster (in sense 2), F. pl[^a]tre. Cf. {Plastic}, {Emplaster}, {Piaster}.] [Formerly written also… …   The Collaborative International Dictionary of English

  • Plaster of Paris — Plaster Plas ter, n. [AS., a plaster (in sense 1), fr. L. emplastrum, Gr. ?, ?, fr. ? to daub on, stuff in; ? in + ? to mold: cf. OF. plastre a plaster (in sense 2), F. pl[^a]tre. Cf. {Plastic}, {Emplaster}, {Piaster}.] [Formerly written also… …   The Collaborative International Dictionary of English

  • Plaster of Paris bandage — Plaster Plas ter, n. [AS., a plaster (in sense 1), fr. L. emplastrum, Gr. ?, ?, fr. ? to daub on, stuff in; ? in + ? to mold: cf. OF. plastre a plaster (in sense 2), F. pl[^a]tre. Cf. {Plastic}, {Emplaster}, {Piaster}.] [Formerly written also… …   The Collaborative International Dictionary of English

  • Plaster stone — Plaster Plas ter, n. [AS., a plaster (in sense 1), fr. L. emplastrum, Gr. ?, ?, fr. ? to daub on, stuff in; ? in + ? to mold: cf. OF. plastre a plaster (in sense 2), F. pl[^a]tre. Cf. {Plastic}, {Emplaster}, {Piaster}.] [Formerly written also… …   The Collaborative International Dictionary of English

Share the article and excerpts

Direct link
Do a right-click on the link above
and select “Copy Link”