AstroFlight

AstroFlight

Astroflight, Incorporated is a manufacturer of products for electric-powered radio controlled aircraft, unmanned aerial vehicles, brushless industrial motors, the world's first solar-powered aircraft and the world's first practical electric radio controlled model airplane. The company is based in Marina Del Rey, California, USA.

Early history

The company was founded in 1969 by Bob Boucher and Roland Boucher. Their goal was the development and production of a high-performance radio controlled sailplane for use in AMA-certified competition. That first sailplane, the "Malibu," finished third in its very first outing in San Jose that same year. Bob Boucher would use a Malibu in 1970 to set a closed-course world record for soaring. His record flight of 302km took place at Waimanelo, Hawaii. The introduction of the Fournier RF-4 electric R/C airplane in 1971 marked the debut of the world's first practical electric-powered model airplane. This would be the model which Roland Boucher would use to set a world record for duration and distance with a flight of one hour and a distance of 29 miles on a single charge. Since no official categories for electric flight existed at the time, neither the AMA nor the FAI recognized the record.

The Northrop Corporation awarded Astro Flight a contract in 1972 to develop a low- altitude electric surveillance drone. Project manager Bob Boucher along with Roland Boucher and their lone employee Dave Shadel finished the design in only six months. The result was the Model 7212 flying wing. With a wingspan of 8', the 7212 was powered by three of the company's Astro 40 ferrite motors each turning a three-blade, 8x8 propeller. The 7212 would set another unofficial record in August 1973 by carrying a 7.5 pound lead payload over a closed course for an hour and twenty minutes at speeds reaching 75 mph.

The world's first solar-powered airplane

Astro Flight was awarded an ARPA contract through Lockheed in 1974 in order to build a demonstrator of "Sunrise I", the world's first solar-powered airplane. The historic flight, powered only by sunlight, took place November 4, 1974 at Fort Irwin, California. Two Astro Flight Astro 40 ferrite motors powered the craft via a 6:1 gearbox swinging a 36x24 wood propeller. More than one thousand solar cells on the wing were the sole source of energy, producing roughly 450 watts of power. The craft, weighing in at 27 pounds with its 32' wingspan, had a service ceiling of 20,000 feet depending on available sunlight. 1975 saw both the departure of Roland Boucher and damage to "Sunrise I" in a windstorm. It also saw the introduction of the improved "Sunrise II", built in just three months. Its maiden flight was on September 27, 1975 at Nellis AFB. Improvements included a single Astro Flight Cobalt 40 motor powered by 4480 solar cells with an output of 600 watts. Climb rate was drastically improved at over 300 feet per minute as was the estimated service ceiling of 75,000 feet, although actual flights did not exceed 20,000 feet due to problems with both command and control.

The world's first human-carrying solar-powered airplane

In 1979, DuPont sponsored Dr. Paul MacCready in his attempt to create a solar powered plane capable of carrying a human. The result was the "Gossamer Penguin" which maidened May 16, 1980 in Shafter, California. It utilized the 600 watt solar panel used to power "Sunrise II" along with a production version Cobalt 40 motor. Thrust was via a three-stage transmission turning an 11' propeller at 120 RPM. Motor speed was 15,000 RPM. The success of "Gossamer Penguin" prompted DuPont to agree to sponsor a solar plane capable of crossing the English Channel. The "Dupont Solar Challenger" required three months to build the solar panels with their 16,128 cells. The setup was capable of 4000 watts at operating altitude and 2500 watts at sea level. A 3.5 horsepower motor, specially designed for the project, turned 9000 RPM through a 22:1 belt-drive reduction unit, meaning a propeller speed of about 400 rpm.

On July 7, 1981, pilot Steve Ptacek piloted the "Dupont Solar Challenger" from Pontoise, France to the Manston RAF base in Kent, England.

Today, Astro Flight continues to provide hobbyists with motors, battery chargers and electronic speed controls. Their model 4005 AC/DC battery charger, introduced in 1982 at the Toledo R/C Show would become an industry standard, with more than 500,000 units produced over the next decade. They serve industrial customers with custom-made brushless motors. Their Astro Model 300 ten-horsepower DC motor is the same one used in the "GM Sunracer" experimental solar powered automobile.

External link and reference

* [http://www.astroflight.com Astro Flight home page]
* [http://www.greencarcongress.com/2007/07/sonex-aircraft-.html#more Sonex e-flight electric aircraft]


Wikimedia Foundation. 2010.

Игры ⚽ Нужно решить контрольную?

Look at other dictionaries:

  • Mauro Solar Riser — Solar Riser Role Electric aircraft National origin United States Manufacturer Ultralight Flying Machines (UFM) Designer Larry Mauro First flight 29 April 1979 Introduction 1979 Retired …   Wikipedia

  • Unmanned aerial vehicle — UAV redirects here. For the entertainment company, see UAV Corp.. For the veterans organization, see Ukrainian American Veterans. A group photo of aerial demonstrators at the 2005 Naval Unmanned Aerial Vehicle Air Demo. An unmanned aerial vehicle …   Wikipedia

  • Marina del Rey, California — Marina del Rey   census designated place   Looking northeast into the heart of Marina del Rey from the CDP s South Jetty area on the evening of Sunday, September 11, 2011 …   Wikipedia

  • Solar Challenger — Infobox Aircraft name = Solar Challenger caption = A drawing of the Solar Challenger type = experimental aircraft national origin = United States manufacturer = AeroVironment designer = Paul MacCready first flight = 1981 introduction = retired =… …   Wikipedia

  • Gossamer Penguin — Infobox Aircraft name = Gossamer Penguin caption = Test flight of the Gossamer Penguin type = experimental aircraft national origin = United States manufacturer = AeroVironment designer = Paul MacCready first flight = 1979 introduction = retired …   Wikipedia

  • Drone — Pour les articles homonymes, voir Drone (homonymie). Boeing ScanEagle sur sa rampe de lancement Un drone (« faux bourdon » en a …   Wikipédia en Français

  • Sunrise — В Викисловаре есть статья «sunrise» Sunrise (произносится Санрайз) может значить …   Википедия

Share the article and excerpts

Direct link
Do a right-click on the link above
and select “Copy Link”