Soviet submarine K-431

The Soviet submarine K-431 (originally the Soviet submarine K-31) was a Soviet nuclear-powered submarine that had a reactor accident on August 10, 1985.^[1] An explosion occurred during refueling of the submarine at Chazhma Bay, Vladivostok.^[2] TIME magazine has identified the accident as one of the world's "worst nuclear disasters".^[1]

Nuclear reactor plant disaster

The K-431, completed around 1965 as unit K-31, was a Project 675 (Echo II) class submarine with two pressurized water reactors, each 70 MW_t capacity and using 20% enriched uranium as fuel.^[3] On 10 August 1985, the submarine was being refueled at the Chazhma Bay naval facility near Vladivostok. The submarine had been refueled and the reactor tank lid was being replaced. The lid was laid incorrectly and had to be lifted again with the control rods attached. A beam was supposed to prevent the lid from being lifted too far, but this beam was positioned incorrectly, and the lid with control rods were lifted up too far. At 10:55 AM the starboard reactor became prompt critical, resulting in a criticality excursion of about 5x10¹⁸ fissions and a thermal/steam explosion. The explosion expelled the new load of fuel, destroyed the machine enclosures, rupturing the submarine's pressure hull and aft bulkhead, and partially destroyed the fueling shack, with the shack's roof falling 70 meters away in the water. A fire followed which was extinguished after 4 hours, after which assessment of the radioactive contamination began. Most of the radioactive debris fell within 50-100 meters of the submarine, but a cloud of radioactive gas and particulates blew to the northwest across a 6 km stretch of the Dunay Peninsula, missing the town of Shkotovo-22, 1.5 km from the dock. The contaminated forest area was later surveyed as 2 square km in a swath 3.5 km long and 200 to 650 meters wide. Initial estimates of the radioactive release were about 2 MCi of noble gases and 5 MCi of other fission products, but most of this was short-lived isotopes; the estimated release inventory one hour after the accident was about 1000 Ci of non-noble fission products. In part because the reactor did not contain spent fuel, the fraction of biologically active isotopes was far smaller than in the case of the Chernobyl reactor accident.

M. Takano et. al. suggest that only 29 GBq of I-131 was released, but larger amounts (620 GBq of I-133 and 1840 GBq of I-135). The same source suggests that the total release was about 259 PBq but due to radioactive decay this decreased to 43 TBq after 24 hours. The same source suggests that the fission yield was 5e18 fissions which would deliver 156 MJ of heat into the reactor.

Ten naval personnel were killed (8 officers and 2 enlisted men), probably by the explosion itself and not from radiation injuries. Radiation injuries were observed in 49 people, with 10 developing radiation sickness; the latter figure included mostly firefighters, some of whom sustained doses up to 220 rad (2.2 Gy) external and 400 rem (4 Sv) to the thyroid gland. Of the 2,000 involved in cleanup operations, 290 were exposed to high levels of radiation compared to normal standards.

High-level waste gathered during clean-up operations was placed in temporary disposal sites. Due to the rapid decay of most of the fission products and the cleanup operations, some dockyard facilities were able to resume operations four days later. About two months post-accident the radioactivity in water in the cove was comparable to background levels, and 5–7 months post-accident the radiation levels were considered normal throughout the dock area. The damaged submarine was towed to Pavlovsk Bay and berthed there.

Consequences

There were 10 fatalities and 49 other people suffered radiation injuries.^[4]

References

1. ^ ^{a b} The Worst Nuclear Disasters
2. ^ CNN (1998). "Cold War: Broken Arrows (1980b)". CNN.com. http://www.cnn.com/SPECIALS/cold.war/experience/the.bomb/broken.arrows/content/1980b.html. Retrieved 2007-06-17. ^{[dead link]}
3. ^ Some sources confuse this submarine with K-314, a Project 671 or Victor I class submarine launched in 1972 and withdrawn from service after a reactor accident in December 1985.
4. ^ The Worst Nuclear Disasters

• Takano, Makoto, Vanya Romanova, Hiromi Yamazawa, Yuri Sivintsev, Keith Compton, Vladimir Novikov, and Frank Parker, Feb. 2001, "Reactivity accident of nuclear submarine near Vladivostok," Journal of Nuclear Science and Technology pages 143 to 157
• Sivintsev, Yu. V., 2003, "Was the Chazhma accident a Chernobyl of the far east?", Atomic Energy
• [1]
• Bellona: Nuclear submarine accidents (This report incorrectly identifies K-431 as Soviet submarine K-314 when describing the refueling criticality accident.

--~Samuel MAUGHERMAN